We're at about 15 hours, so we're not quite ready for our 20-hour service. However, I'm going out of town and it seemed like the right time to take care of a slew of warranty issues; they can have the boat for 10 days. Nearly all of this list was noted at delivery over five weeks ago.
The biggest item is redoing the navy blue gelcoat stripe directly above the bumper rail. After being told by FW and the dealer the discoloration would fade and match, it has not. It's sat outside in the heat and sun for over five weeks and has not "dried out" or cured. Therefore, we want to take care of it now and make sure it's perfect versus waiting until the end of year when it's winterized.
Here is a list I compiled:
● Gelcoat & Exterior
-Replace stripes all the way around
-Gelcoat around bow hook rubbed off where trailer rollers make contact – porous
-Redo entire Navy stripe of Gelcoat above bumper rail (discolored from factory)
-Chip in gelcoat above port side transom hook
● Trailer
-Missing bow strap
-Rust on back
-Replace frayed winch strap
● Upholstery & Canvas
-Bimini needs adjusting – starboard short strut bent, crooked when lowered, off-center
-Replace seat back cushion stern, torn
-Walk-thru transom bottom cushion “hook” loose
● Engine
-Engine clicking or ticking at idle
-Acoustic foam falling off
-Engine hatch doesn't line up, sticks when closing
● Steering “clunks” periodically
● Floor squeaks or creaks a lot, normal?
● Stereo buzzing
|
