www.iFourWinns.com
https://www.smwebhead.com/phpBB3/

HELP!!!!
https://www.smwebhead.com/phpBB3/viewtopic.php?f=3&t=517		 Page 1 of 1
Author:  bugsdoc1 [ Sat Dec 09, 2006 12:30 am ]
Post subject:  HELP!!!!
My 06 200 SS Horizon has NO port (opening) for the the BILGE PUMP!!!!


IT should be above the exhaust port on the Starboard side!!



Any one ELSE have this problem!!!! :shock: :shock:
Author:  jvalich [ Sun Dec 10, 2006 10:54 pm ]
Post subject: 
I'm confused :? Are you saying there is no output line from the bilge pump overboard thru-hull, i.e. no thru-hull?
Author:  bugsdoc1 [ Mon Dec 11, 2006 12:33 am ]
Post subject: 
YES!!!!!
:(

The only thru-hull is for the drink/beverage storage by the Radio!!

Thanks for the feedback!!

NO WONDER WE have been having Water Problems!
Author:  Midlife Crisis [ Mon Dec 11, 2006 12:59 pm ]
Post subject: 
Can you post any pictures?
Author:  jvalich [ Mon Dec 11, 2006 1:01 pm ]
Post subject: 
So, there is no line from the exit of the pump to a thru-hull.. Sounds like you need to have the dealer remedy the situation via the warranty.

How much water has collected in the boat? Depending, you might have other issues that surface later with things such as the starter if it had gotten wet. You definitely want to have them make note of the water that has been able to collecting the boat because of the issue.
Author:  bugsdoc1 [ Tue Dec 12, 2006 11:16 pm ]
Post subject: 
WE WILL BE TAKING BACK AGAIN TO PHIL DILL FOR PROPER REPAIR!

 :( :( :( :roll:
Author:  Txjole [ Mon Mar 05, 2007 1:39 pm ]
Post subject: 
Thats wild. My bilge have yet to kick on other then when I wash the inside. Even after a good hosing down by the local Fire Dept. at a tie-up.
Author:  trhardy1 [ Mon Mar 05, 2007 6:04 pm ]
Post subject: 
That is a hairball, no doubt. I have only had my bilge on while cleaning. I would document everything and make sure you don't get caught up in some warranty nightmare later, such as - the engine mfr saying the problem was due to the FW hull. I know that when I had engine troubles last year, my dealer dealt with a Volvo Penta rep on the issue - not FW, though they were copied on the incident.

You might have to throw out some threatening language to get satisfaction. Please keep us informed - and good luck, Captain.
Author:  4WINNS4ME [ Sun Mar 11, 2007 8:03 pm ]
Post subject: 
its strange that something like that could be missed doesn't somebody have to hook up a line from the pump to the thru-hull? and they don't notice there is no hole. def. keep us informed i'm curious to see what happens
Author:  bugsdoc1 [ Sat Mar 17, 2007 4:02 pm ]
Post subject: 
Boat was returned to Phil Dill this morning. We met with sales manager, service manager and their lead service tech. They had never seen this on a four winns before. Digital pics were taken to be sent to Four winns. The tech will go through the whole boat and check for damage. Starter has already been replaced once. :roll: Hopefully we can get all of the issues resolved and enjoy this boating season.
Author:  bugsdoc1 [ Fri Apr 20, 2007 4:03 pm ]
Post subject:  Update for ALL!!!
:D The 200 SS was picked up on 04/11 with the following repairs!

Found that Thru-Hull was not installed during build.
Installed fitting to allow bilge to discharge. Lake test performed to determine correct operation.

Adjusted post for engine hatch latch.

Replaced split and peeling graphics.

Ladder Lid has air void. R & R Rear ladder lid.

Filled boat with fuel as a courtesy!

Summerize I/O. NO Charge!

R&R Impeller. Volvo Impeller Service. NO Charge!

Check Coupler. Brake Fluid low. Fill and Bleed Brake System. NO Charge

Battery Strap brocken. REPLACED!

Dash Shrouds coming apart. Added lock nuts and washers. Secured!

Gauge lights not working and switch panel not lighting up.
Rewire Dash and Switch Panel.

Ground strap for trailer lights not hooked up.
Hooked up ground strap.

We also requested a Mooring Cover which Four Winns PAID for.

It appears we are now ready for this season!!!!!!!!!!!!!

I will keep you posted. Phil Dill and Four Winns stood behind their Product and I Really appreciate that!

They also agreed to a FREE winterization at the end of the season!!
Author:  jvalich [ Fri Apr 20, 2007 4:23 pm ]
Post subject: 
Excellent!. Now get out thre and enjoy that boat! :D
Author:  230 Mike [ Fri Apr 20, 2007 7:22 pm ]
Post subject: 
Jeez. Makes me wish they'd left my bilge fitting off.

Congratulations!
Author:  4WINNS4ME [ Fri Apr 20, 2007 7:42 pm ]
Post subject: 
wow! glad to see everthing worked out for you.
Page 1 of 1 All times are UTC - 6 hours [ DST ]
Powered by phpBB® Forum Software © phpBB Group
http://www.phpbb.com/