www.iFourWinns.com
https://www.smwebhead.com/phpBB3/

Annual service time - what to do?
https://www.smwebhead.com/phpBB3/viewtopic.php?f=3&t=6291		 Page 1 of 1
Author:  SeriousRob [ Mon Aug 02, 2010 12:17 pm ]
Post subject:  Annual service time - what to do?
Hi all,
I just returned from a 3 week vacation in Maine. My 2001 Horizon 180 (5.0 Volvo/Penta) ran great the whole time. :D Only had one instance of a squealing alternator....fixed with a shot of WD-40 and have a spare alternator on hand.
Last year I did all of the rountine service myself; engine oil and filter change, cap and rotor, fuel filter, coil, plugs, lubing of cables, and outboard oil. All of this was fairly easy.
This year I will do the same but was wondering if there is more I should look into. If there is more, how much work is involved and can I do it myself? I am very good with the inboard engine work but have never pulled an outdrive or worked on one. I have the SELOC manual as well.
Thanks for any help provided.
Rob
Author:  M3eater [ Tue Aug 03, 2010 1:04 pm ]
Post subject:  Re: Annual service time - what to do?
I would just add lubing the gimbal bearing and u-joints, which does require removal of the drive. It's not all that difficult. You can build a jig (or rack) to hold the drive as you pull it off. I built one from lumber and used my floor jack under it. Others here have done similar. The manual will guide you through the general process.
Author:  Matt2000horizon180 [ Tue Aug 03, 2010 2:14 pm ]
Post subject:  Re: Annual service time - what to do?
Hey Rob..

I did a little more my first year as I need to replace bellows since they had a tear.

This post has too much detail but may give some tips....I just posted my own notes.

viewtopic.php?f=3&t=2523&start=0&st=0&sk=t&sd=a
Page 1 of 1 All times are UTC - 6 hours [ DST ]
Powered by phpBB® Forum Software © phpBB Group
http://www.phpbb.com/